My Tatty Caddy
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
My Tatty Caddy
I've finally got myself a Caddy after years of wanting one.
I'd never needed a van but the man maths said it was cheaper as a daily driver than my ST170 estate
The van has already had a few nice bits done to it. It was put together by the owner of a local VAG specialist so although rough around the edges, it was super good mechanically.
Here's the van as I got it.
20201117_154152 by Richard Lewin, on Flickr
Bits it's had done,
Touran front end
New wings
V Maxx coilovers
Golf GTI mk5 brakes all round
Remapped
Side exit exhaust
Mk6 GTI stereo
Mk7 Golf R seats on Touran bases
Engine wise it's had an EGR delete, new cam shaft, sensors, belts, umps and pulleys.
There's a few other bits that I can't remember off the top of my head.
It'll be a bit liberating having the van and keeping it a bit tatty on the outside. I usually search high and low for a car, spend loads getting it perfect and then move on. It'll be nice to not be afraid to leave it in a car park
I'd never needed a van but the man maths said it was cheaper as a daily driver than my ST170 estate
The van has already had a few nice bits done to it. It was put together by the owner of a local VAG specialist so although rough around the edges, it was super good mechanically.
Here's the van as I got it.
20201117_154152 by Richard Lewin, on Flickr
Bits it's had done,
Touran front end
New wings
V Maxx coilovers
Golf GTI mk5 brakes all round
Remapped
Side exit exhaust
Mk6 GTI stereo
Mk7 Golf R seats on Touran bases
Engine wise it's had an EGR delete, new cam shaft, sensors, belts, umps and pulleys.
There's a few other bits that I can't remember off the top of my head.
It'll be a bit liberating having the van and keeping it a bit tatty on the outside. I usually search high and low for a car, spend loads getting it perfect and then move on. It'll be nice to not be afraid to leave it in a car park
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
The first job for the Caddy - clean the interior.
A good 14 years worth of grimy mitts all over the dash and door cards.
20201118_135554 by Richard Lewin, on Flickr
20201118_135558 by Richard Lewin, on Flickr
20201118_135602 by Richard Lewin, on Flickr
I got scrubbing with a few brushes.
20201118_135702 by Richard Lewin, on Flickr
Top side of the hand brake lever cleaned
20201118_140541 by Richard Lewin, on Flickr
20201118_142900 by Richard Lewin, on Flickr
This is the dirt that came from the dash, door cards and centre console.
20201118_145508 by Richard Lewin, on Flickr
Cleaned
20201118_141119 by Richard Lewin, on Flickr
20201118_143648 by Richard Lewin, on Flickr
Then onto the headlining and seats.
Didn't get any photos of the top bits.
20201118_145834 by Richard Lewin, on Flickr
20201118_145837 by Richard Lewin, on Flickr
The dirt pulled from the passenger seat base.
20201118_151731 by Richard Lewin, on Flickr
Clean and fresh
20201118_151751 by Richard Lewin, on Flickr
All dried out.
20201119_123120 by Richard Lewin, on Flickr
20201119_123123 by Richard Lewin, on Flickr
20201119_123127 by Richard Lewin, on Flickr
20201119_123142 by Richard Lewin, on Flickr
20201119_123147 by Richard Lewin, on Flickr
20201119_123152 by Richard Lewin, on Flickr
20201119_123202 by Richard Lewin, on Flickr
I'd like to do the Touran carpets at some point, and maybe the door cards too but I haven't looked at the options for windy windows.
A good 14 years worth of grimy mitts all over the dash and door cards.
20201118_135554 by Richard Lewin, on Flickr
20201118_135558 by Richard Lewin, on Flickr
20201118_135602 by Richard Lewin, on Flickr
I got scrubbing with a few brushes.
20201118_135702 by Richard Lewin, on Flickr
Top side of the hand brake lever cleaned
20201118_140541 by Richard Lewin, on Flickr
20201118_142900 by Richard Lewin, on Flickr
This is the dirt that came from the dash, door cards and centre console.
20201118_145508 by Richard Lewin, on Flickr
Cleaned
20201118_141119 by Richard Lewin, on Flickr
20201118_143648 by Richard Lewin, on Flickr
Then onto the headlining and seats.
Didn't get any photos of the top bits.
20201118_145834 by Richard Lewin, on Flickr
20201118_145837 by Richard Lewin, on Flickr
The dirt pulled from the passenger seat base.
20201118_151731 by Richard Lewin, on Flickr
Clean and fresh
20201118_151751 by Richard Lewin, on Flickr
All dried out.
20201119_123120 by Richard Lewin, on Flickr
20201119_123123 by Richard Lewin, on Flickr
20201119_123127 by Richard Lewin, on Flickr
20201119_123142 by Richard Lewin, on Flickr
20201119_123147 by Richard Lewin, on Flickr
20201119_123152 by Richard Lewin, on Flickr
20201119_123202 by Richard Lewin, on Flickr
I'd like to do the Touran carpets at some point, and maybe the door cards too but I haven't looked at the options for windy windows.
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
Then the outside.
20201119_105945 by Richard Lewin, on Flickr
20201119_110012 by Richard Lewin, on Flickr
20201119_111434 by Richard Lewin, on Flickr
20201119_111459 by Richard Lewin, on Flickr
A quick clean up with some all purpose cleaner.
20201119_112750 by Richard Lewin, on Flickr
20201119_112919 by Richard Lewin, on Flickr
Window rubbers were full of crud.
20201119_113034 by Richard Lewin, on Flickr
Getting better.
20201119_123224 by Richard Lewin, on Flickr
20201119_125119 by Richard Lewin, on Flickr
20201119_135245 by Richard Lewin, on Flickr
The guy I bought the car from welded the sill and bunged some stone chip stuff on it.
Blasted any loose bits off with an airline.
20201127_144436 by Richard Lewin, on Flickr
The old door roller had fallen to bits so a new one was fitted.
20201125_090655 by Richard Lewin, on Flickr
20201125_092517 by Richard Lewin, on Flickr
A little bit of clearance over the wheel.
20201125_092037 by Richard Lewin, on Flickr
The door shut needs some tudying up at a later date.
20201125_092030 by Richard Lewin, on Flickr
Quickly rubbed down the sill and wings and got busy with a rattle can
It's supposed to be the right colour (matched from the colour code on the fuse box) so it might look better if the rest is cleaned up properly.
Before
20201127_151041 by Richard Lewin, on Flickr
After
20201127_151403 by Richard Lewin, on Flickr
20201127_151445 by Richard Lewin, on Flickr
The windscreen kept getting super wet too... turns out there were no buns in the roof rail holes.
The sound deadening under the floor was dry so that's a bonus.
Cut up some bits of paint protection film.
20201127_153437 by Richard Lewin, on Flickr
Trimmed - that should keep it good for a little while. Plugs are on order.
20201127_153733 by Richard Lewin, on Flickr
That's it up until now
20201127_162910 by Richard Lewin, on Flickr
20201119_105945 by Richard Lewin, on Flickr
20201119_110012 by Richard Lewin, on Flickr
20201119_111434 by Richard Lewin, on Flickr
20201119_111459 by Richard Lewin, on Flickr
A quick clean up with some all purpose cleaner.
20201119_112750 by Richard Lewin, on Flickr
20201119_112919 by Richard Lewin, on Flickr
Window rubbers were full of crud.
20201119_113034 by Richard Lewin, on Flickr
Getting better.
20201119_123224 by Richard Lewin, on Flickr
20201119_125119 by Richard Lewin, on Flickr
20201119_135245 by Richard Lewin, on Flickr
The guy I bought the car from welded the sill and bunged some stone chip stuff on it.
Blasted any loose bits off with an airline.
20201127_144436 by Richard Lewin, on Flickr
The old door roller had fallen to bits so a new one was fitted.
20201125_090655 by Richard Lewin, on Flickr
20201125_092517 by Richard Lewin, on Flickr
A little bit of clearance over the wheel.
20201125_092037 by Richard Lewin, on Flickr
The door shut needs some tudying up at a later date.
20201125_092030 by Richard Lewin, on Flickr
Quickly rubbed down the sill and wings and got busy with a rattle can
It's supposed to be the right colour (matched from the colour code on the fuse box) so it might look better if the rest is cleaned up properly.
Before
20201127_151041 by Richard Lewin, on Flickr
After
20201127_151403 by Richard Lewin, on Flickr
20201127_151445 by Richard Lewin, on Flickr
The windscreen kept getting super wet too... turns out there were no buns in the roof rail holes.
The sound deadening under the floor was dry so that's a bonus.
Cut up some bits of paint protection film.
20201127_153437 by Richard Lewin, on Flickr
Trimmed - that should keep it good for a little while. Plugs are on order.
20201127_153733 by Richard Lewin, on Flickr
That's it up until now
20201127_162910 by Richard Lewin, on Flickr
-
- Hyper Poster
- Posts: 1005
- Joined: Fri Jul 21, 2017 5:33 pm
- Engine size/power: 1.8 20V Turbo
Re: My Tatty Caddy
Good effort, well done
- Lcm evolution
- Caddy Fan
- Posts: 60
- Joined: Wed Nov 02, 2016 8:11 pm
- Engine size/power: 1.9 TDI (74bhp)
Re: My Tatty Caddy
Nice to see mate , did the new hinge help much mine is the same i am a new owner off the caddys aswell im starting a build thread ,
are the gti brakes much bigger mate ?
are the gti brakes much bigger mate ?
-
- Caddy2k Groupie
- Posts: 24
- Joined: Fri Nov 27, 2020 7:07 pm
- Engine size/power: 1.6 CR TDI (102bhp)
Re: My Tatty Caddy
Crazy wheels but, why not
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
Cheers guys
Now it's silky smooth.
The Caddy would've had 280 front and 260 discs on the rear.
The GTI ones are 312 front, 280 rear.
They definitely stop the van quickly.
I wasn't keen on the wheel colour at first but it's growing on me.
Yeah, it makes a huge difference. It was just metal on metal before and horrible to open and close.Lcm evolution wrote: ↑Sun Nov 29, 2020 9:45 pm Nice to see mate , did the new hinge help much mine is the same i am a new owner off the caddys aswell im starting a build thread ,
are the gti brakes much bigger mate ?
Now it's silky smooth.
The Caddy would've had 280 front and 260 discs on the rear.
The GTI ones are 312 front, 280 rear.
They definitely stop the van quickly.
I wasn't keen on the wheel colour at first but it's growing on me.
Last edited by scratcher on Mon Nov 30, 2020 11:28 pm, edited 1 time in total.
-
- Caddy Fan
- Posts: 72
- Joined: Mon Nov 30, 2020 10:44 am
- Engine size/power: 2.0 TDI (140bhp)
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
The temptation is there to polish it over Christmas, but the paint really is terrible.
Whoever took the old sign writing off was in a hurry and took half the lacquer with it. Pretty much the only panel without lacquer peel is the passenger door
The rattle can job was left inside over the weekend.
The colour match isn't too bad out in the daylight
20201201_123738 by Richard Lewin, on Flickr
-
- Caddy2k Groupie
- Posts: 31
- Joined: Wed Aug 26, 2020 5:12 am
Re: My Tatty Caddy
Cracking job - that hand brake lever
What did you use on the interior?
What did you use on the interior?
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
Cheers bud
The handbrake was grim. I wish I took a photo of it before I started. It was brown all the way around.
I used ODK Wax Encore and a steamer on the interior plastics.
Finished off with ODK Cabin. Smells lovely now
-
- Caddy2k Groupie
- Posts: 38
- Joined: Sun Nov 08, 2020 3:26 pm
- Engine size/power: 1.9 TDI (104bhp)
Re: My Tatty Caddy
It's been a while since I've really done anything with the Caddy.
I bought an Aux lead so now I can listen to Spotify in the van just a cheap and cheerful ebay job. Plugged in the head unit nice and easy.
I'd like to swap the little tray under the ash tray for a later one so I can have a nice Aux socket.
Does anyone know if the ASR switch from a later model plugs straight in or is there some wire swapping to be done?
And since I can't leave anything alone, I stated trying to make it look less tatty, while still being a bit tatty
Number plate off, ready for a good clean.
20210115_130304 by Richard Lewin, on Flickr
Cleaned off lots of old glue residue.
20210115_134359 by Richard Lewin, on Flickr
And got busy with some vinyl.
20210115_170652 by Richard Lewin, on Flickr
Just the bumper and wing (mostly) done for now.
I need to polish the sides of the van and I can get some vinyl on there too. It's covered in swirls and buffer trails and it'll bug me seeing it through the gaps in the camo.
I bought an Aux lead so now I can listen to Spotify in the van just a cheap and cheerful ebay job. Plugged in the head unit nice and easy.
I'd like to swap the little tray under the ash tray for a later one so I can have a nice Aux socket.
Does anyone know if the ASR switch from a later model plugs straight in or is there some wire swapping to be done?
And since I can't leave anything alone, I stated trying to make it look less tatty, while still being a bit tatty
Number plate off, ready for a good clean.
20210115_130304 by Richard Lewin, on Flickr
Cleaned off lots of old glue residue.
20210115_134359 by Richard Lewin, on Flickr
And got busy with some vinyl.
20210115_170652 by Richard Lewin, on Flickr
Just the bumper and wing (mostly) done for now.
I need to polish the sides of the van and I can get some vinyl on there too. It's covered in swirls and buffer trails and it'll bug me seeing it through the gaps in the camo.
-
- Hyper Poster
- Posts: 893
- Joined: Wed Jun 17, 2020 12:10 pm
- Location: Ireland Dublin
Re: My Tatty Caddy
Tatty Caddy spruces up nice Scratcher.
-
- Hyper Poster
- Posts: 893
- Joined: Wed Jun 17, 2020 12:10 pm
- Location: Ireland Dublin
-
- Caddy2k Groupie
- Posts: 5
- Joined: Thu Oct 29, 2020 12:04 pm
- Engine size/power: 1.6 CR TDI (102bhp)
- Location: Essex
- Contact:
Re: My Tatty Caddy
WOW do you want to clean mine??
Amazing job, what did you use on the door cards, centre console and dash?
this van is coming along nicely, I keep looking at wrapping but I'm unsure.
Loving this one though, good job!
Keep posting updates, I'm interested to see how this turns out.
Amazing job, what did you use on the door cards, centre console and dash?
this van is coming along nicely, I keep looking at wrapping but I'm unsure.
Loving this one though, good job!
Keep posting updates, I'm interested to see how this turns out.